In seats and textiles cleaning, the cleaning result can be improved by using a hot solution, instead of room temperature solution.

Specific tests show that cleaning carpet with just 10°C more can give the same result as cleaning twice.

Santoemma machines can be equipped with an instant heater that allows you to immediately heat the water used for cleaning. In this way a much better result is obtained in cleaning seats and textiles, even very dirty.

The maximum temperature is limited to 65-70°C in order not to damage the textiles. These temperatures allow you to effectively clean and sanitize seats and fabrics.

The use of hot water also reduces the drying time and is appreciated for working in winter and in cold areas.

A special dense foam is sprayed on the textiles and is sucked after some seconds.

Dense foam does not penetrate deep inside the textiles, therefore allowing a short drying time: seats can be dry in 20 minutes!

In order to obtain the special dense foam, the chemical solution is mixed with compressed air, obtained by a dedicated air compressor. The quality of foam is therefore much better than the "liquid foam" of machines without compressor. Thanks to its optimal density, dense foam penetrates for few millimeters in the superficial layer where the dirt lies. It does not remain only on the surface, as it happens with "dry foam" . Therefore, dense foam allows an excellent cleaning result, even without any mechanical brushing action. The manual tool is very light and compact, for cleaning many seats quickly and without effort. Its shape also allows you to reach any corner.

Moreover, the Santoemma dense foam extractors can be equipped with  a special gun for turbo nebulization@50micron to completely sanitize the car interior after the cleaning of upholstery. This gun can spray a mix of air and very small liquid particles, with a diameter of 50micron only.

Their small size allows the particles to float in the air jet and to easily reach every point of the environment. The sanitizing jet can reach points 4 meters away from the operator. By directing the jet properly, small environments can be saturated quickly and evenly.

With 50micron turbo-nebulization the particles leave very little moisture on the surfaces, setting evenly and leaving them only slightly moist for a few minutes. In this way the chemical is able to act for the necessary time to perform its sanitizing action. The car is ready to use immediately after the sanitizing treatment. The sanitizing particles are nebulized into the passenger compartment, saturating it, and reaching even the most difficult to reach places, including air conditioning ducts.

The innovative accessory for the turbo-nebulization@50micron allows you to use a single Santoemma machine for:

• cleaning and sanitizing car and vehicle upholstery with the dense foam extraction system
• sanitizing completely the car interiors, by nebulizing a sanitizing chemical.

The two operations can be performed with the most appropriate frequency, according to the specific needs.

Santoemma dense foam extractors can be equipped with an optional device for generating dry fog@7micron. This system allows you to carry out the complete sanitization of vehicle interiors without wetting the surfaces. Therefore it is ideal for ambulances and emergency vehicles.

With the Kit for dry fog@7micron it is possible to quickly sanitize interiors of large vehicles, such as trucks, coaches, trams, buses, shuttles, subways cars. The machine is left out of the vehicle. Only the chemical tank with the dry fog dispenser are placed inside and they are connected to the machine through a 10-meter hose. The whole interior can be saturated in a few minutes with no need for the operator to stay inside.

This system, patented by Santoemma, uses hot dense foam which ensures excellent cleaning results even in case of extremely dirty upholstery and an even shorter drying time.

This system is particularly appreciated to work in winter and in cold areas.

The hot foam is immediately available as the machine is switched on.

Moreover, the Santoemma dense foam extractors can be equipped with a special gun for turbo nebulization@50micron to completely sanitize the car interior after the cleaning of upholstery. This gun can spray a mix of air and very small liquid particles, with a diameter of 50 micron only.

Their small size allows the particles to float in the air jet and to easily reach every point of the environment. The sanitizing jet can reach points 4 meters away from the operator. By directing the jet properly, small environments can be saturated quickly and evenly.

With 50micron turbo-nebulization the particles leave very little moisture on the surfaces, setting evenly and leaving them only slightly moist for a few minutes. In this way the chemical is able to act for the necessary time to perform its sanitizing action. The car is ready to use immediately after the sanitizing treatment. The sanitizing particles are nebulized into the passenger compartment, saturating it, and reaching even the most difficult to reach places, including air conditioning ducts.

The innovative accessory for the turbo-nebulization@50micron allows you to use a single Santoemma machine for:

• cleaning and sanitizing car and vehicle upholstery with the dense foam extraction system
• sanitizing completely the car interiors, by nebulizing a sanitizing chemical.

The two operations can be performed with the most appropriate frequency, according to the specific needs.

Santoemma dense foam extractors can be equipped with an optional device for generating dry fog@7micron. This system allows you to carry out the complete sanitization of vehicle interiors without wetting the surfaces. Therefore it is ideal for ambulances and emergency vehicles.

With the Kit for dry fog@7micron it is possible to quickly sanitize interiors of large vehicles, such as trucks, coaches, trams, buses, shuttles, subways cars. The machine is left out of the vehicle. Only the chemical tank with the dry fog dispenser are placed inside and they are connected to the machine through a 10-meter hose. The whole interior can be saturated in a few minutes with no need for the operator to stay inside.

When cleaning textiles, the drying time after vacuuming strongly depends on the vacuum strength.

A specially designed High Waterlift vacuum system is equipped on Santoemma machines, allowing to get up to 50% higher waterlift than standard extractors. This results in an extremely shorter drying time than with normal machines. Not only the drying time is reduced, but also a better cleaning result is obtained, since the extra solution extracted from fibers contains extra dirt removed from the surface. The same residual dirty solution, if left evaporating on textiles as it normally happens, would leave the surface not so clean as with high waterlift machines.

The machines of Santoemma CAR Wash program can be used in different areas.

By clicking on the area, it is possible to view the most suitable machines.